Torpedo VAZ-2107: description and characteristics

2024 Author: Erin Ralphs | [email protected]. Last modified: 2024-02-19 11:42

All cars are equipped with gauges and locking sensors. They serve to control the operation of the engine and other important systems. The VAZ-2107 torpedo is no exception. The driver can prevent the failure of the nodes if he responds to the instrument readings in a timely manner. Consider the features of the panel of the domestic machine, the possibility of its improvement and other features.

Notation

The VAZ-2107 torpedo is an important component of the entire structure. The dashboard layout looks like this:

1. Vehicle voltmeter.
2. Speedometer indicating travel speed.
3. Odometer (mileage counter that the car has passed).
4. Meter showing the speed of the crankshaft. Its technical name is a tachometer. The screen has several zones painted in different colors. The yellow compartment is the operation of the motor at high speeds, the red part is invalid modes. The maximum speed of this machine is 6 thousand revolutions per minute.
5. Refrigerant temperature indicator. If the arrow is in the green zone, this is the norm. Overheating of the power unit is accompanied by a mark in redparts of the indicator. If the coolant temperature exceeds 118 degrees Celsius, it is strongly not recommended to operate the car.
6. Indicator of economical operation of the motor (econometer). Its arrow should be in the green zone.
7. Vehicle warning lamp assembly.
8. Activation of repeated signals (turns).

Other indicators

The VAZ-2107 torpedo has a number of signaling devices. Among them:

• Engine control malfunction sensor (relevant on models with fuel injection system). The indicator glows orange when the ignition is on. After starting the power unit, it goes out. If the light flashes quickly and stays on, contact a repair shop. The operation of the machine is allowed, the system goes into standby mode.
• Battery charging signal. When starting the engine, the indicator lights up red and goes out. If the lamp continues to glow, you should pay attention to the battery charge. The main causes of the malfunction are: poor tension of the timing belt, a malfunction of the generator, or disturbances in the electrical circuit. If this problem is ignored, it will completely drain the battery and, in some cases, cause a fire.
• Side light indicator (when turned on, it lights up green).

Additional indicators

The VAZ-2107 torpedo, the photo of which is presented above, has several more important indicators, namely:

• Sensors for activating high beam headlights. In this case, the lamp lights up in blue.
• Oil pressure controller. If this indicator is sufficient, when the motor is turned on, the indicator glows red and immediately goes out. If the light stays on for a long time, it indicates low oil pressure. Ignoring this problem can lead to failure of the vehicle's power plant.
• Parking brake control mode (its activation is indicated by the corresponding lamp, which lights up red after starting the engine).
• Indicator of daily mileage.
• Fuel Remaining Sensor. If there are about 5 liters of fuel left in the tank, it will light up amber.
• The main indicator of the level of gasoline.

Key type switches

VAZ-2107 torpedo overlay has special sockets for key switches. Among them:

• External lighting controller. It has three positions. The first indicates that the system is deactivated, the second indicates that the license plate and size lights are on, the third indicates that the dipped beam is on.
• Auto switch for heated rear window. You can turn it on after starting the engine.
• Car rear fog light switch. The regulator is activated simultaneously with the low beam headlights.
• Heater fan controller. With it, you can select the desired circulation speed of the air supplied by the heater.

In addition, the VAZ-2107 torpedo is equipped with lettercontrol indicators, namely:

• Signal "A" indicates unfastened seat belts (shines red when the ignition is turned on).
• "B" - lights up in orange, indicates the operation of the heated rear window.
• "B" - an indicator of the emergency operation of the brake unit of the machine. Illuminates red when the fluid level in the hydraulic brake reservoir is critically low.

Causes for emergency indicators to light up

Tuning the VAZ-2107 torpedo involves the best external design and original lighting. But the overall functionality is preserved in the traditional style. Among the most common emergencies, the following points are noted:

1. If the oil pressure level sensor lights up, turn off the engine. Then it is necessary to check the presence of oil, add if the level is below the permissible level. The further glow of the indicator indicates that it is required to tow the car to a service station or other place of repair. If the problem is ignored, situations are possible when the engine connecting rods knock and the unit is further jammed. This is fraught with the replacement of the engine or its overhaul.
2. If the battery warning light is on, check the terminals for a secure fit and oxidation. The second reason for the sensor to trip is a malfunction of the generator. It is advisable to turn off all electrical devices and visit the nearest repair station. A good rechargeable battery, even in such conditions, can work for about 100kilometers if the power is supplied exclusively to the ignition system. As a rule, the problem occurs due to a breakdown of the voltage regulator relay.
3. The VAZ-2107 torpedo on the VAZ-2106 has the same characteristics as in the standard version. For example, if the emergency brake fluid indicator lights up, you must immediately turn off the engine and stop. Then you need to check the fluid level, top up if necessary. If the brake system does not work, you must call a tow truck and contact a repair specialist.

What else to look out for?

Some dashboard indicators also require special attention. For example, if the liquid boiling indicator is in the red zone, you must literally immediately stop the car and let the motor cool down. Considering that such a sensor is not provided on the early versions of the Zhiguli, a novice driver may not notice this moment. But the problem is usually accompanied by steam escaping from under the hood. It is worth noting that you should not immediately touch the working parts of the engine, as you can get badly burned. Most often, a malfunction occurs due to an insufficient level of refrigerant, a breakdown of the thermostat or radiator fan. Service station specialists or the skills of owners who have been driving for more than a year will help solve the problem.

The fuel level indicator indicates its minimum supply by turning on the red light. This happens if less than five liters of fuel remain in the tank. The problem is being solvedsimple - you need to refuel the car at the nearest gas station. In addition, you need to pay attention to the parameters of the tachometer. Keeping the arrow of the device in the green zone (no more than 5 thousand revolutions per minute) allows you to provide the most economical driving mode.

How to remove a torpedo on a VAZ-2107?

This operation consists of several main steps:

1. The car is being prepared for the initial stage (the indicated manipulations are in the instructions for servicing and repairing the vehicle).
2. The negative battery terminal is being disconnected.
3. Use a screwdriver or similar tool to pry the handle block from the heater control levers.
4. Then unscrew the nut located on the meter reset knob. The washer is also removed, the handle is pushed into the space behind the dashboard.
5. Use a thin screwdriver or a pike to pry off and remove the plug of the screw that fixes the dashboard.
6. The main screw is unscrewed with a Phillips screwdriver.
7. The overlay for the VAZ-2107 torpedo and the panel itself are carefully dismantled.
8. Disconnect the speedometer cable and the tri-color wiring harnesses.

At the final stage, the panel is removed, after which it is possible to replace the backlight, control lights, and other elements. Install the part in reverse order.

Modernization

Tuning the VAZ-2107 torpedo allows you to fundamentally change the equipment of the car interior. In today's market, you can easily findall necessary parts and accessories. First of all, the owners change the main backlight. This solution improves the appearance of the torpedo and eases the strain on vision.

There are a number of other improvements, in the implementation of which the correct technical approach and the owner's imagination play a significant role. Alternatively, you can mount white or multi-colored instrument dials that look out of the box, giving the design a completely new style.

It would be useful to replace the radio with a new and modern audio system. Fortunately, there are a great many modifications, which makes it easier to choose based on the capabilities and wishes of the user. More advanced tuning is best left to specialists. Nevertheless, it is also possible to improve the VAZ-2107 torpedo with your own hands without significant financial costs.

What do the owners think?

Consumers note that the dashboard on the machine in question is equipped with all the necessary minimum instruments and buttons required to control and manage the main systems. Nevertheless, the owners complain about the nondescript design of the part, as well as weak lighting.

The VAZ-2107 torpedo, reviews of which are very controversial, was developed taking into account new trends in the automotive industry. However, it lacks modern design and sophisticated functionality. There is nothing surprising. Still, this car belongs to the budget category.

Which torpedo is suitable for the VAZ-2107?

Many owners are not satisfied with the dashboard of the "seven". In the first modifications, a variation was established,almost identical to the fifth model. In this case, not only the aesthetic appearance of the torpedo causes inconvenience, but also a practical problem. The glove compartment lock has to be fixed with improvised means, since it constantly opens.

An analog from the VAZ-2115 is perfect for replacing the dashboard. The only problem during installation will be the appearance of gaps that can be carefully sealed with foam.

A torpedo can also be installed on the VAZ-2107 from a foreign car. The best option is the part from the BMW E30. In addition, an analogue of the Toyota Camry is often used. In this case, you will need to slightly cut the part on the sides, install power windows and choose the right cover for the steering wheel.

LED backlight

Often, when modernizing the interior of the Zhiguli, users remember LED backlighting. It gives the interior originality, is easy to install and does not require large expenses. To equip the panel, you will need a dozen LEDs, which are interconnected by means of a special cable. A piece of wire with a Molex connector is used as a latch. You will also need a pair of 680 ohm resistors.

Installing a VAZ-2107 torpedo with new lighting will require several basic steps to be followed:

1. First, the LED heads are cut off with a file. After that, the entire surface is sanded, which will allow you to get a more uniform and soft glow.
2. Further prepared wirecut into pieces of half a centimeter and bent in the form of the letter "G". The form of placement of new lighting is selected (in a circle, in corners or diametrically). The edges of the wiring are carefully soldered in the right place.
3. The next step is to solder each leg of the LED. This makes it possible to control the on and off of the backlight directly from the control unit, directing the glow in the right direction.
4. Next, cut the cable by cleaning the LEDs. This will form the main wiring, consisting of four main elements located around a large fixture. With side counterparts, they are soldered by means of several small wires. As a result, a single chain is created. Minus and plus of the system is taken from the old design.
5. At the end, you will need to adjust the brightness of the glow. This can be done using the adjustment knob. This parameter is adjusted in a pair of circuits equipped with a central four diodes.

Installing a VAZ-2107 torpedo in this way makes it possible to move on the roads, but with special care.

Instrument arrows

Improving the highlighting of the arrows will require certain tools. For this you will need:

• Two pairs of 3mm white LED bulbs.
• Resistors 1.5 ohms each.
• Plastic glass elements 4 mm long.
• Special paint or nail polish.
• Protection caps for the body of arrows and plugs.
• Good(universal) glue, scales and wires.

Next, you need to decide on the length of the arrow. If we take the size of 30 mm, then it is necessary to add a margin for the fixing space to it. When turning an element from plexiglass, you need to follow the arrow configuration, providing a flat base and a pointed edge. This will allow you to get optimal illumination and even distribution of energy.

The opposite edge of the arrow is ground at an angle of 45 degrees. The element is varnished, preferably red, and fixed to the panel with a furniture plug, planted on glue. Then the standard arrow and the finished home-made analogue are weighed. If the readings exceed the difference of 100 milligrams, the part is brought to the required parameters. White scales and LEDs are inserted into the dashboard. This process requires special attention and accuracy. New bulbs on the sides are tinted with black paint, which will reduce light loss. Next, the LEDs are fixed to the scale and the devices are tested.

Result

As practice shows and the reviews of the owners confirm, the interior of the Zhiguli can be improved without significant costs. For example, a torpedo from BMW on the VAZ-2107 allows you to upgrade not only the appearance of the panel, but also its functionality. The details of the improvement have been mentioned above. We hope that the tips will not be useless, but will improve your car, regardless of the year of manufacture and general characteristics.